HPC INDUSTRIAL SERVICES LLC
DBA DIS INDUSTRIAL SERVICES HYDRO SERVICES
USDOT 547892MC-Docket MC852564NORWELL, MA
Review before tenderingHazmat-authorized1,123 power units
HPC INDUSTRIAL SERVICES LLC (USDOT 547892) in NORWELL, MA — has findings to review before tendering. FMCSA authority, fleet size, BASIC safety measures, crash and inspection history.
- Has active operating authority that's tenderable today (common or contract).
- No pending authority revocation.
- Not under an uncleared federal out-of-service or safety action.
- BIPD on file: $1,000,000.
- No cargo insurance on file. Required for many shipper contracts.
- No history of insurance lapses.
- Satisfactory safety rating.
- No BASIC alerts in any of the five public SMS categories.
- Driver and vehicle out-of-service rates are at or below the national roadside average.
- 8 preventable crash(es) in the last 24 months; recordable crash rate not available.
- No fatal crashes in the last 24 months.
- No link to a prior revoked authority.
- Authority involuntarily revoked 3 times, most recent 2022-07-07 — recurring instability (typically insurance-lapse / reinstate cycles).
- 10 other active carrier(s) operate from this exact street + ZIP. High counts are often legitimate registered-agent / virtual-office addresses — treat as context, not a verdict.
- FMCSA compliance review on file dated 2010-11-02 (C).
- Crash Indicator and Hazmat Compliance BASICs are statutorily withheld from public SMS under the FAST Act — their absence is not a clean record; use the crash-risk signals above instead. The Hazmat Compliance BASIC is also withheld for this hazmat carrier.
Built from FMCSA's public Safety Management System data — guidance, not legal advice. Verify directly with the carrier and your cargo policy before tendering.
Authority
- Common authority
- Active
- Contract authority
- Not applicable
Safety & BASIC scorecard
BASIC safety measures
Unsafe driving
No alert
measure 0.06
Hours of service
No alert
measure 0.16
Driver fitness
No alert
measure 0.04
Controlled substance
No alert
measure 0
Vehicle maintenance
No alert
measure 3.72
Under the FAST Act, FMCSA publishes an absolute per-category measure (not a 0–100 percentile) for these five BASICs — the alert flag, not the raw number, is the risk signal. The Crash Indicator and Hazmat Compliance BASICs are statutorily withheld from public view.
Last 24 months
0
Fatalities
6
Injuries
9
Crashes
156
Inspections
30
OOS inspections
34
OOS violations
Insurance
- BIPD on file
- $1,000,000
- Cargo insurance
- No
- Bond on file
- No
Fleet
- Power units
- 1,123
- Total drivers
- 973
- Years in business
- 32
- Hazmat authority
- Yes
Crash risk
- Preventable crashes (24 mo)
- 8 of 9 total crash(es)
- Recordable crash rate
- Not available
- Driver OOS rate
- 2.4%
- Vehicle OOS rate
- 20.1%
The official Crash Indicator BASIC is withheld from public SMS under the FAST Act — these derived signals stand in for it; their absence is not a clean record.
Compliance & history
- Reincarnation / chameleon
- No prior revoked authority
- Involuntary revocations
- 3 times last 2022-07-07
- Physical address
- 10 other carrier(s) at this address
- Federal OOS / safety action
- None on file
- MCS-150 self-report
- 2026-03-13
- Insurance lapse history
- No lapses on record
- Last compliance review
- 2010-11-02 · C
Inspection history (all-time)
238
Inspections
48
OOS inspections
305
Violations
58
OOS violations
1
Post-accident
Record spans 2023-05-30 → 2026-05-20.
Crash history (last 24 months)
2026-03-19
TX
Tow-away
2026-03-03
TX
1 injuredTow-away
2026-02-20
CA
2 injuredTow-away
2025-10-23
CA
2 injuredTow-away
2025-07-18
LA
Tow-away
2025-02-13
OH
Tow-away
2025-02-04
LA
1 injuredTow-away
2025-01-20
IL
Tow-away
2024-09-17
IN
Tow-away
2024-04-25
TX
Tow-away
Violation pattern (all-time, by area)
No cited violations on record for this carrier.
Recent violations (last 24 months, worst first)
| Date | Category | Violation | OOS |
|---|---|---|---|
| 2026-04-20 | Vehicle Maintenance | Roll-on/Roll-off/Hook Lift Containers - Improper securement of a roll-on/roll-off and hook lift container | OOS |
| 2026-04-20 | Vehicle Maintenance | Lighting - Stop lamps - Both inoperative when required to be on | OOS |
| 2026-04-20 | Vehicle Maintenance | Operating a CMV without documentation of a periodic inspection | — |
| 2026-04-10 | Vehicle Maintenance | Operating a CMV without documentation of a periodic inspection | — |
| 2026-03-31 | Vehicle Maintenance | Air Brake - Damaged by heat or broken | — |
| 2026-03-31 | Vehicle Maintenance | Conspicuity Systems - Truck tractor lower rear retro reflective sheeting missing on vehicle manufactured on or after Jul | — |
| 2026-03-31 | Vehicle Maintenance | Conspicuity Systems - Truck tractor upper rear retro reflective sheeting missing on vehicle manufactured on or after Jul | — |
| 2026-03-25 | Vehicle Maintenance | Tires - All others leaking or inflation less than 50% of the maximum inflation pressure on tire not equipped with ATIS | OOS |
| 2026-03-25 | Vehicle Maintenance | Drum Brake - Contaminated friction surface | — |
| 2026-03-25 | Vehicle Maintenance | Brake Out of Adjustment - Roto Clamp (Short & Long) DD-3 or Bolt | — |
| 2026-03-25 | Vehicle Maintenance | Brake - Defective brake(s) are equal to or greater than 20% of the service brakes on the vehicle/combination | OOS |
| 2026-03-25 | Vehicle Maintenance | State/Local Laws - Wheel (mud) flaps missing or defective | — |
| 2026-03-15 | Hazardous Materials Compliance | Failed to comply with exemption | — |
| 2026-03-02 | Vehicle Maintenance | Operating a CMV without proof of a periodic inspection | — |
| 2026-03-02 | Vehicle Maintenance | Inoperable Required Lamp | — |
| 2026-02-26 | Vehicle Maintenance | Tire-other tread depth less than 2/32 of inch measured in a major tread groove | — |
| 2026-02-23 | Unsafe Driving | Driver - Failed to use seat belt while operating a CMV | — |
| 2026-02-12 | Hazardous Materials Compliance | HM (Shipping Papers) - Shipper HM shipping paper does not list emergency response telephone number as required | — |
| 2026-02-12 | Hazardous Materials Compliance | HM (Emergency Response) - No emergency response information | — |
| 2026-02-12 | Hazardous Materials Compliance | HM (Shipping Papers) - Motor carrier permit/require a driver to operate a motor vehicle without a proper shipping paper | — |
| 2026-02-12 | Vehicle Maintenance | Emergency Equipment - Stopped vehicle warning devices missing or improper | — |
| 2026-02-12 | Vehicle Maintenance | Lighting - Clearance lamp(s) inoperative | — |
| 2026-02-12 | Vehicle Maintenance | Lighting - Identification lamp(s) inoperative | — |
| 2026-02-12 | Vehicle Maintenance | Washers - Inoperative washing system. | — |
| 2026-01-30 | Vehicle Maintenance | Brake - Breakaway not attached to the towing vehicle | OOS |
| 2026-01-27 | Vehicle Maintenance | Tires - All others leaking or inflation less than 50% of the maximum inflation pressure on tire not equipped with ATIS | OOS |
| 2026-01-27 | Vehicle Maintenance | Air Brake - Hose/tubing damaged or not secured | — |
| 2026-01-26 | Vehicle Maintenance | Emergency Equipment - Stopped vehicle warning devices missing or improper | — |
| 2026-01-17 | Unsafe Driving | Driver - Failed to use seat belt while operating a CMV | — |
| 2026-01-13 | Vehicle Maintenance | Air Brake - ABS malfunction lamp defective on trailers manufactured on or after March 1 1998 | — |
| 2026-01-13 | Vehicle Maintenance | Operating a CMV without documentation of a periodic inspection | — |
| 2026-01-10 | Vehicle Maintenance | Tires - All others leaking or inflation less than 50% of the maximum inflation pressure on tire not equipped with ATIS | OOS |
| 2026-01-08 | Vehicle Maintenance | No or defective lighting devices or reflective material as required | — |
| 2025-12-23 | Unsafe Driving | State/Local Laws - Failed to obey a traffic control device - Permanent or Temporary - e.g. safety official signal sign l | — |
| 2025-12-16 | Hours-of-Service Compliance | Driver failed to maintain supply of blank drivers records of duty status graph-grids | — |
| 2025-11-26 | Vehicle Maintenance | Wipers - Inoperative / missing / damaged wipers | — |
| 2025-11-12 | Vehicle Maintenance | Brake Hose or Tubing Chafing and/or Kinking - Connection to Power Unit | — |
| 2025-11-12 | Vehicle Maintenance | No/improper securement of roll/hook container | OOS |
| 2025-11-12 | Vehicle Maintenance | Emergency Equipment - A power unit requiring fuses - missing a spare fuse for a required part or accessory (e.g. lamps r | — |
| 2025-10-28 | Unsafe Driving | State/Local Laws - Speeding 6-10 miles per hour over the speed limit | — |
| 2025-10-16 | Vehicle Maintenance | Tire-flat and/or audible air leak | OOS |
| 2025-10-09 | Vehicle Maintenance | Air Brake - Hose/tubing damaged or not secured | — |
| 2025-09-08 | Vehicle Maintenance | Stop lamp violations | — |
| 2025-09-08 | Vehicle Maintenance | No or defective automatic trailer brake | OOS |
| 2025-08-25 | Vehicle Maintenance | Air Brake - Hose/tubing damage into the outer reinforcement ply. | OOS |
| 2025-08-25 | Vehicle Maintenance | Lighting - Headlamp(s) - Any inoperative | — |
| 2025-07-24 | Vehicle Maintenance | Hydraulic/Electric Brake - Inoperative other than a steering axle. | — |
| 2025-07-24 | Vehicle Maintenance | Operating a CMV without documentation of a periodic inspection | — |
| 2025-07-24 | Vehicle Maintenance | Brake - Defective brake(s) are equal to or greater than 20% of the service brakes on the vehicle/combination | OOS |
| 2025-07-21 | Vehicle Maintenance | No or defective automatic trailer brake | OOS |
Recent inspections (with violations, newest first)
No inspections with violations on record for this carrier.
Verify on FMCSA
FMCSA is the system of record. One click through to the official source.